低压加热器危急疏水频繁动作的治理

华电技术 ›› 2011, Vol. 33 ›› Issue (3): 52-54.

低压加热器危急疏水频繁动作的治理

李兴敏

华电国际邹县发电厂，山东邹城273522

收稿日期:1900-01-01 修回日期:1900-01-01 出版日期:2011-03-25 发布日期:2011-03-25

Treatment of the frequent action fault of the emergency steam trap valve in low pressure heater

LI Xingmin

Huadian International Zouxian Power Plant, Zoucheng 273522, China

Received:1900-01-01 Revised:1900-01-01 Online:2011-03-25 Published:2011-03-25

摘要/Abstract

摘要： 华电国际邹县发电厂 #5机组 #8B低压加热器危急疏水在机组高负荷时频繁动作，对机组的安全、经济运行带来不利影响。对故障原因进行了排查，指出 #6低压加热器至 #7A低压加热器的正常疏水调门弹簧断裂造成低压加热器系统B侧疏水量大于A侧，从而导致 #8B低压加热器危急疏水频繁动作。更换调门的弹簧和密封圈后，危急疏水不再频繁动作。


关键词: 低压加热器, 疏水, 管道, 弹簧, 调试

Abstract: The emergency steam trap valve of low pressure(LP) heater number 8B of unit number 5 in Huadian International Zouxian Power Plant was frequently acted under condition of high load, and this bring unfavorable influence on safety and economical operation of the unit. The reason of the fault was investigated. It is found by the investigation that the spring of regulating valve, which is installed in the normal drain pipe from LP heater number 6 to LP heater number 7A, was broken, and this caused the quantity of drain water in B side of LP heater system is larger than that in A side, and further caused the emergency steam trap valve of LP heater number 8B to act frequently. After the spring and the sealing ring were replaced, the emergency steam trap valve no longer acts frequently.

Key words: low pressure heater, steam trap, pipe line, spring, debugging

李兴敏. 低压加热器危急疏水频繁动作的治理[J]. 华电技术, 2011, 33(3): 52-54.

LI Xingmin. Treatment of the frequent action fault of the emergency steam trap valve in low pressure heater[J]. Huadian Technology, 2011, 33(3): 52-54.

[1]	陈泽泓, 廖锷, 吴磊, 曹淇, 陈国强, 杜广瀚, 刘桂秀, 李根. 太阳能光热电站熔融盐管道支吊架应力分析[J]. 综合智慧能源, 2022, 44(4): 85-91.
[2]	刘义斌, 刘旋坤, 宋刚, 杨欣华, 张缦, 杨海瑞. 350 MW超临界煤粉锅炉全燃准东煤的运行优化研究[J]. 华电技术, 2021, 43(12): 79-84.
[3]	刘明1，朱伟雄2，丁勇能2，白佳1. 启机阶段高温蒸汽管道弯头温度场及热应力分析[J]. 华电技术, 2019, 41(9): 18-21.
[4]	宋馨. V94.3A型燃气轮机点火失败原因分析及解决方案[J]. 华电技术, 2019, 41(8): 24-26.
[5]	杨亚龙，李春庆，王永，赵颖. 沉管过河施工中供热管道的安全性验算分析[J]. 华电技术, 2019, 41(6): 61-63.
[6]	宋战兵1，范佩佩2，魏江1，刘宝林1，李根2，种道彤2. 蒸汽管道刚性支吊架应力分析[J]. 华电技术, 2019, 41(4): 1-5.
[7]	李强. 淄博热电WESP水系统优化实践[J]. 华电技术, 2019, 41(4): 71-73.
[8]	张大佳，杨鹏. 6F.01燃气轮机液压油系统调试故障分析及处理[J]. 华电技术, 2019, 41(3): 29-31.
[9]	王林，刘金秋，夏晓涛. 某450MW燃机冷再三通裂纹原因分析与处理[J]. 华电技术, 2019, 41(2): 32-35.
[10]	张方，修正平，方津. 低低温省煤器经济性计算及应用[J]. 华电技术, 2019, 41(2): 65-72.
[11]	赵龙，岳义博. 大型储能电站智能辅助调试系统的设计及应用[J]. 华电技术, 2019, 41(11): 53-56.
[12]	李晓飞1，张赞1，解建坤2，闻小明2，刘宇清2. 基于反声降噪的风机管道流场优化与节能应用[J]. 华电技术, 2019, 41(1): 27-31.
[13]	汪小峰1，陈锐2. 某电厂主蒸汽管道振动原因分析及治理[J]. 华电技术, 2018, 40(7): 32-34.
[14]	包桓铭，刘柯楠. 国内某核电站循环水系统调试工期优化方案研究[J]. 华电技术, 2018, 40(7): 70-73.
[15]	卜峥嵘1，程勇明2，安付立2，刘宾2. 高温高压蒸汽管道振动分析治理[J]. 华电技术, 2018, 40(5): 41-44.