Reason analysis and treatment of high acid and alkali consumptions of first stage desalinization equipment

Abstract

Abstract: The reasons of higher acid and alkali consumptions of first stage desalinization equipment in Sichuan Guang’an Power Generation Company Limited project phase I were analyzed. The concrete regulating measures were proposed, and the optimal resin regeneration process was formulated. After the regulation, the acid and alkali consumption of the desalinization system for anion exchange resin and cation exchange resin regeneration decreased obviously, and the economic efficiency of the resin regeneration of desalinization system was increased.

Key words: first stage desalinization, acid and alkali consumption, anion exchange resin and cation exchange resin, reason analysis, measure

DENG Ying. Reason analysis and treatment of high acid and alkali consumptions of first stage desalinization equipment[J]. Huadian Technology, 2012, 34(12): 58-60.

[1]	LI Fangyi, LI Nan, ZHOU Yan, XIE Wu. Prediction on the regional carbon emission factor for power generation based on multi-dimensional data and deep learning [J]. Integrated Intelligent Energy, 2023, 45(8): 11-17.
[2]	LIU Yixian, WANG Yubin, YANG Qiang. High fault-tolerant distribution network state estimation method based on gated graph neural network [J]. Integrated Intelligent Energy, 2023, 45(6): 1-8.
[3]	LIU Xiuru, LI Peipei, WANG Xianpeng, LU Xuge, WANG Zhiqiang. Review and prospect of researches on boilers´ flue gas acid dew point [J]. Huadian Technology, 2020, 42(9): 45-55.
[4]	YANG Mingming. Research on wind turbine power curve based on Nacelle Transfer Function [J]. Huadian Technology, 2020, 42(5): 50-54.
[5]	LIU Zhimin1,2, DING Yang1, XU Tingting1,BAI Yunshan1. Research on gas turbine combustion pressure fluctuation and the key technologies for its measurement [J]. Huadian Technology, 2019, 41(9): 1-5.
[6]	LI Haiyang，WANG Renlei，YOU Liangzhou，HENG Shiquan. Experimental study of dissolved oxygen’s effect on dissolved hydrogen analyzer of the main steam [J]. Huadian Technology, 2019, 41(7): 27-30.
[7]	WANG Xueli. Reasons analysis for tube blasting and preventive measures for superheater of 1000MW supercritical boiler [J]. Huadian Technology, 2019, 41(7): 70-72.
[8]	YE Luo，WU Jundong，CHEN Xian. Operation analysis of low temperature economizer system [J]. Huadian Technology, 2019, 41(6): 50-52.
[9]	WANG Zhoujun1,2，LI Xinghua2，TANG Lijun1，DUAN Quansheng2. Study on flow mixing and equalizing technique of primary air at inlet of medium speed coal mills [J]. Huadian Technology, 2019, 41(5): 17-21.
[10]	ZHANG Jibing，QIAO Xiaosan. Calculation and comparison of carbon emissions based on the default value and measured value of raw coal emission factor [J]. Huadian Technology, 2019, 41(3): 73-75.
[11]	SONG Xin. Analysis and solution for temperature fluctuation of turbine shaft seal steam [J]. Huadian Technology, 2019, 41(2): 46-48.
[12]	CAI Liangliang，GONG Shimin，TANG Bin，LI Shuai，ZHANG Lin，YUAN Quan. Research on automatic and seamless switching technology for virtual backup measurement and control units in smart substations [J]. Huadian Technology, 2019, 41(10): 30-34.
[13]	ZHU Hao. Discussion on the problem of power supply with different grids in thermal power plant [J]. Huadian Technology, 2018, 40(9): 25-27.
[14]	ZHENG Liwen. Measures to improve heating capacity of thermoelectric gas turbine in South Xinjiang Thermal Power Plant [J]. Huadian Technology, 2018, 40(9): 28-29.
[15]	HUANG Chengbin, ZHANG Yulin. Method for improving measurement accuracy of soft ground backfilling project [J]. Huadian Technology, 2018, 40(8): 21-22.

Reason analysis and treatment of high acid and alkali consumptions of first stage desalinization equipment

Knowledge

Cited

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments