The Energy-saving Effect Analysis of Replacing Condensate Pump by Drain Pump of Low Pressure Heater at Starting and Shutting Process

Huadian Technology ›› 2008, Vol. 30 ›› Issue (8): 71-72.

• 新能源 • Previous Articles Next Articles

The Energy-saving Effect Analysis of Replacing Condensate Pump by Drain Pump of Low Pressure Heater at Starting and Shutting Process

JIANG Xu-liang, LIU Qing-he

Huaneng Huaiyin Power Plant, Huaian 223000, China

Received:1900-01-01 Revised:1900-01-01 Published:2008-08-25

Abstract

Abstract: The technical characteristics of drain pump of low pressure heater and condensate pump were described, and their technical parameters were compared each other, then a reformation plan was put forward which demands replacing the condensate pump by drain pump at starting and shutting process. The energy-saving effect is notable after the reformation realized.

Key words: drain pump of low pressure heater, condensate pump, starting and shutting process, energy-saving effect

JIANG Xu-liang;LIU Qing-he. The Energy-saving Effect Analysis of Replacing Condensate Pump by Drain Pump of Low Pressure Heater at Starting and Shutting Process[J]. Huadian Technology, 2008, 30(8): 71-72.

[1]	XU Jiang，LIANG Haishan，XUE Xiaoyu. Optimization of deep frequency conversion transformation for condensate pump in 1000MW secondary reheat unit [J]. Huadian Technology, 2019, 41(8): 70-73.
[2]	SHANG Ziwen. Cause analysis of highlevel dissolved oxygen in condensate water of a 660MW unit [J]. Huadian Technology, 2018, 40(8): 34-35.
[3]	WANG Lu. Fault and treatment of condensate system during startup of 660MW unit [J]. Huadian Technology, 2018, 40(4): 52-53.
[4]	CAO Jingfang, WU Changhao, LI Menglin. Vertical condensate pump motor overvibration cause analysis and treatment [J]. Huadian Technology, 2017, 39(7): 54-56.
[5]	ZONG Xudong. Analysis on power consumption rate of condensate pump and optimization reformation [J]. Huadian Technology, 2015, 37(1): 71-72.
[6]	WU Zhiwei. Method of making up water for boiler during pipe sweeping with low cost [J]. Huadian Technology, 2014, 36(6): 52-53.
[7]	WEI Shengluan. Application of variable frequency control technology in condensate pump system [J]. Huadian Technology, 2014, 36(5): 23-27.
[8]	WANG Chuansheng. Treatment and case analysis of high power consumption rate in Harbin Third Power Plant [J]. Huadian Technology, 2014, 36(2): 16-17.
[9]	QU Haiying, SUN Lei. Analysis on reasons causing dissolved oxygen in condensate water of 1000MW unit to exceed standard and control measures [J]. Huadian Technology, 2014, 36(2): 69-72.
[10]	WEI Xiaofeng 1, HU Xuejun 2. Analysis on variable frequency reformation of condensate pump of 2×350MW unit [J]. Huadian Technology, 2013, 35(9): 47-48.
[11]	XIAO Chengming. Optimization of variable frequency control strategy for condensate pump [J]. Huadian Technology, 2013, 35(3): 9-10.
[12]	XING Lijun;MA Yongsheng. Analysis on operation control mode of condensate pump of 1 000 MW unit [J]. Huadian Technology, 2013, 35(3): 5-7.
[13]	WANG Hui, CHEN Zhenbo, LI Jun. Treatment of vibration of 1000MW unit condensate pump after variable frequency reformation [J]. Huadian Technology, 2013, 35(11): 70-71.
[14]	LIU Hongyu;WANG Liying;ZONG Yanxia. Application of highvoltage variable frequency technology in energysaving reformation of condensate pump of 1000MW unit [J]. Huadian Technology, 2012, 34(4): 60-63.
[15]	HONG Li. Analysis on reason of rapid dropping of condensate pump output power and countermeasures [J]. Huadian Technology, 2012, 34(10): 55-56.

The Energy-saving Effect Analysis of Replacing Condensate Pump by Drain Pump of Low Pressure Heater at Starting and Shutting Process

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments