Experimental research on combustion optimization for 600MW subcritical boiler

Huadian Technology ›› 2013, Vol. 35 ›› Issue (1): 10-15.

• 研究与开发 • Previous Articles Next Articles

Experimental research on combustion optimization for 600MW subcritical boiler

LI Qiang1, CHEN Min2

1.Zhejiang Guohua Zheneng Power Generation Company Limited, Ningbo 315612, China; 2.Suzhou Branch of Xi’an Thermal Power Research Institute Company Limited, Suzhou 215011, China

Received:1900-01-01 Revised:1900-01-01 Online:2013-01-25 Published:2013-01-25

Abstract

Abstract: Aiming at the 600MW subcritical drum boiler of Guohua Ninghai Power Plant, an experiment of combustion optimization control was carried out. Under different load, some measures, such as to change the air distribution mode, to reduce the parameters of the primary air and to control the oxygen properly, were adopted. Under various load points, the power consumption of the three fans (the induced draft fan, the forced draft fan and the primary air fan) was reduced. The mass concentration of the NOx emission was reduced. The overall economic efficiency of the boiler was improved. Simultaneously, the capacity margin of the fans was increased. According to the experimental results, the boiler optimal operation instruction sheets were formulated, which can be used as reference for economic operation of boiler of power plant.

Key words: subcritical boiler, combustion optimization control, air distribution mode, oxygen, NOxemission

LI Qiang;CHEN Min. Experimental research on combustion optimization for 600MW subcritical boiler[J]. Huadian Technology, 2013, 35(1): 10-15.

[1]	XU Yangsen, ZHANG Lei, BI Lei. Development and challenges of intermediate-temperature proton-conducting solid oxide fuel cells [J]. Integrated Intelligent Energy, 2022, 44(8): 68-74.
[2]	LIANG Yuan, FU Yanfeng, FANG Xiaofeng, CHENG Hongyan, MENG Chunlin, YAN Yingying, CHEN Beiyang. Energy neutral analysis of sewage treatment plant based on AB method under the background of carbon neutrality [J]. Huadian Technology, 2021, 43(6): 55-60.
[3]	ZHAO Linlin. Experiment on energy saving optimization test of desulfurization and oxidation fans for 350MW units [J]. Huadian Technology, 2019, 41(9): 45-48.
[4]	TONG Hang，LI Guomin，WANG Baoyu，RUAN Huifeng，SUN Liang. Estimation method for exhaust gas flow and energy of gas internal combustion engine [J]. Huadian Technology, 2019, 41(7): 6-9.
[5]	SHANG Ziwen. Cause analysis of highlevel dissolved oxygen in condensate water of a 660MW unit [J]. Huadian Technology, 2018, 40(8): 34-35.
[6]	YU Li1,2. A scheme to reduce the exhaust temperature of the HRSG in the regional gas distribution system [J]. Huadian Technology, 2018, 40(4): 42-44.
[7]	HU Heng, XIAO Chengming. Treatment of slightly exceeding dissolved oxygen in condensate water of thermal power plant [J]. Huadian Technology, 2018, 40(10): 52-53.
[8]	CAO Yusheng1, YAO Qi1, CAI Qingqiang2. Cause analysis and treatment of abnormal oxygen content in the water tank of boron and water makeup system of nuclear power plant reactor [J]. Huadian Technology, 2018, 40(10): 73-75.
[9]	LI Xiaohui1, SHI Yan1, QIU Zhibin1, ZHANG Jinwen1, GUO Yanjun1, WANG Xinghe2. Corrosion status investigation and prevention measures of low pressure evaporator in a heat recovery boiler of gas power plant [J]. Huadian Technology, 2017, 39(8): 13-16.
[10]	WANG Fengping, LI Jian, ZHAO Aimin. Reason analysis and prevention measures of inner wall corrosion of a boiler lowtemperature reheater [J]. Huadian Technology, 2017, 39(8): 32-35.
[11]	GAO Qiangsheng1,ZHAO Suping2. Analysis on the reason and countermeasure about low pressure rotor blade corrosion in 300MW steam turbine unit [J]. Huadian Technology, 2016, 38(7): 43-46.
[12]	CHEN Shuke, YU Shengjie, XUE Senxian. Mass concentration control strategy of NOx at the inlet of denitration device [J]. Huadian Technology, 2016, 38(4): 51-53.
[13]	LIU Peihong, ZHANG Xiaodong. Operation oxygen optimization and adjustment for ultra supercritical boiler [J]. Huadian Technology, 2016, 38(3): 44-47.
[14]	CHEN Hui, XUE Hai, HUANG Qilong, DAI Weibao. Adjustment of oxygen content deviation at economizer outlet of a 330MW subcritical W—flame boiler [J]. Huadian Technology, 2016, 38(12): 28-30.
[15]	WANG Chengliang. Analysis on reasons of low boiler efficiency of a 300 MW unit [J]. Huadian Technology, 2015, 37(5): 74-76.

Experimental research on combustion optimization for 600MW subcritical boiler

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments