Analysis on type selection and application of waste heat recovery device of boiler periodic blow down flash tank

Abstract

Abstract: Abstract:Taking the Guojiawan Power Plant of Shenhua Shendong Electric Power Company Limited as example, the necessity of exhaust steam recovery was analyzed. The exhaust steam recovery method of periodic blow down flash tank of power plant boiler was introduced. After a waste heat recovery device had been installed additionally on the periodic blow down flash tank of the boiler, the problem of environment pollution was solved, and the energy utilization rate was improved.

Key words: Key words:boiler, periodic blow down flash tank, waste heat utilization, recovery

XIE Yongsheng. Analysis on type selection and application of waste heat recovery device of boiler periodic blow down flash tank[J]. Huadian Technology, 2013, 35(8): 67-69.

[1]	LIU Xiuru, LI Peipei, WANG Xianpeng, LU Xuge, WANG Zhiqiang. Review and prospect of researches on boilers´ flue gas acid dew point [J]. Huadian Technology, 2020, 42(9): 45-55.
[2]	JIANG Ting1,2，XU Jingjing1,2，MA Qin1,2，YU Li1,2. Economic analysis of low temperature flue gas waste heat utilization in distributed energy system [J]. Huadian Technology, 2019, 41(5): 46-49.
[3]	HOU Xiaoning1，Abu Dhabi Krimu·ABU DHATI2. Application analysis on high back pressure heating technology for supercritical intercooling unit [J]. Huadian Technology, 2019, 41(2): 36-38.
[4]	LI Li. Utilization mode and benefit analysis of biomass biogas power generation [J]. Huadian Technology, 2018, 40(12): 48-49.
[5]	LIU Yubin1, YANG Bo2, MIAO Sen3, CHEN Yaobin1, KONG Fei1. Simulation analysis of draught fan fault for waste heat utilization system of a certain gas turbine power plant [J]. Huadian Technology, 2016, 38(11): 72-75.
[6]	ZHOU Chongbo1, CHENG Xueshan2, REN Huaimin3. A research on measuring and calculating methods of energy saving benefit for the circulating water wasteheat utilization project in thermal power plant [J]. Huadian Technology, 2014, 36(7): 62-64.
[7]	DOU Pengfei. Problems occurred in circulating water waste heat utilization reformation of a power plant and solutions [J]. Huadian Technology, 2014, 36(12): 59-61.
[8]	WANG Tiankun. Application of novel fluoroplasticmade lowtemperature economizer in thermal power plant [J]. Huadian Technology, 2014, 36(12): 20-22.
[9]	LIU Chunxiao, ZHANG Ligang, WANG Zhongli, XIE Yongsheng. Analysis on application of steam exhaust waste heat recovery technology of Guojiawan Power Plant [J]. Huadian Technology, 2013, 35(8): 39-40.
[10]	FU Hao, ZHAO Dongdong. Analysis on measurement error of drum water level measuring device of boiler and improvement measures [J]. Huadian Technology, 2013, 35(8): 36-38.
[11]	LUO Haihua. Design of waste heat utilizing system for cooling circulating water of air compressors [J]. Huadian Technology, 2013, 35(6): 80-81.
[12]	LI Peng. Analysis on differentials of coking characteristics of 200MW boilers [J]. Huadian Technology, 2013, 35(12): 36-39.
[13]	DAI Jun 1,ZHOU Chongbo 2. The impact of water side fouling coefficient in heat pump unit on the project economic of waste heat utilization in power plant [J]. Huadian Technology, 2013, 35(11): 90-92.
[14]	SHEN Yuhui;TAO Aiping;DENG Huipeng. Research on utilization of residual heat in lowtemperature flue gas of coalfired power plant [J]. Huadian Technology, 2012, 34(9): 67-69.
[15]	GUO Zengliang;YUAN Xiongjun. Reformation and optimization for waste heat recovery of rollingcylinder slag cooler in 490t/h CFB heatsupply unit [J]. Huadian Technology, 2010, 32(12): 40-43.

Analysis on type selection and application of waste heat recovery device of boiler periodic blow down flash tank

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments