积灰对直接空冷凝汽器性能影响的分析

华电技术 ›› 2012, Vol. 34 ›› Issue (11): 56-59.

积灰对直接空冷凝汽器性能影响的分析

陈俊丽

华电重工股份有限公司，北京100048

收稿日期:1900-01-01 修回日期:1900-01-01 出版日期:2012-11-25 发布日期:2012-11-25

Analysis about influence of ash deposition on performance of direct aircooled steam condenser

CHEN Junli

Huadian Heavy Industriy Company Limited, Beijing 100077, China

Received:1900-01-01 Revised:1900-01-01 Online:2012-11-25 Published:2012-11-25

摘要/Abstract

摘要： 分析了直接空冷凝汽器的工作特性，以2个单元为模型（一个单元翅片管表面积灰，另一个单元保持洁净状态），通过理论计算，得出了空冷岛局部积灰后空冷凝汽器各区域相关参数的变化规律。结果表明，直接空冷凝汽器在发生局部积灰以后，积灰区域承担的有效散热量减少，凝结蒸汽量降低，洁净单元所承担的散热量、凝结蒸汽量随着积灰单元积灰的增加而逐渐增大，空气温升也显著升高。

关键词: 直接空冷凝汽器, 局部积灰, 温升, 凝结蒸汽量

Abstract: The operating characteristics of the direct aircooled steam condenser were analyzed. Taking two units as examples (there is ash deposition in the fin tube's face of one unit, and the other unit is clean.), the variation law of the parameters of each area of the aircooled condenser with ash deposition in partial area was obtained by theoretic calculation.The results show that the effective heat radiation of the direct aircooled condenser with ash deposition is decreased, and the amount of the condensed steam is also decreased. Along with the increase of the ash deposition in the dirty unit, the heat radiation and the amount of the condensed steam of the clean unit increase gradually, and the air temperature rise also increases obviously.

Key words: direct air-cooled steam condenser, ash deposition in partial area, temperature rise, amount of condensed steam

陈俊丽. 积灰对直接空冷凝汽器性能影响的分析[J]. 华电技术, 2012, 34(11): 56-59.

CHEN Junli. Analysis about influence of ash deposition on performance of direct aircooled steam condenser[J]. Huadian Technology, 2012, 34(11): 56-59.

[1]	贾利峰. 邻机加热技术在1000MW超超临界机组的应用[J]. 华电技术, 2019, 41(4): 66-67.
[2]	邱永罡. 燃机联合循环机组直接空冷凝气器选型优化[J]. 华电技术, 2018, 40(5): 13-16.
[3]	刘钊，任天宝. 铜川电厂空预器差压升高的原因分析及处理[J]. 华电技术, 2018, 40(2): 52-53.
[4]	王刚. 凝汽器真空度降低原因分析及诊断方法[J]. 华电技术, 2015, 37(3): 34-37.
[5]	王红娜，祁怀胜，王庆光，李换利. 蒸发式凝汽器在设计中应注意的问题[J]. 华电技术, 2014, 36(6): 63-64.
[6]	王滨，王兰林，吴涛，刘尊平 . 除氧器启动初期振动现象的分析及消除[J]. 华电技术, 2014, 36(1): 52-53.
[7]	孙启德;;马英. 基于计算流体力学软件的直接空冷单元流场特性分析[J]. 华电技术, 2012, 34(12): 15-17.
[8]	纪强;石宗国;石立斌. 600MW发电机定子线棒温度高的原因分析[J]. 华电技术, 2010, 32(3): 23-24.
[9]	黄建. 异步电机由温升引起振动的故障处理[J]. 华电技术, 2010, 32(11): 44-46.