600MW亚临界供热机组除氧器上水调门晃动处理

华电技术 ›› 2013, Vol. 35 ›› Issue (11): 52-53.

600MW亚临界供热机组除氧器上水调门晃动处理

(华电内蒙古能源有限公司包头分公司，内蒙古包头〓014013)

出版日期:2013-11-25 发布日期:2013-12-30

Treatment measures of rapid change of water inlet valve opening on the deaerator of 600MW subcritical heatsupply unit

(Baotou Power Generation Branch of Huadian Inner Mongolia Energy Company Limited, Baotou 014013, China)

Online:2013-11-25 Published:2013-12-30

摘要/Abstract

摘要： 摘要：600MW机组因凝结水量变化大致使除氧器上水调门晃动严重，水位调节无法投入自动，由于管路高频振动导致定位器频繁损坏。对凝结水管道振动原因进行了分析，提出了改造方案。改造后，未再发生凝结水量波动而导致上水调门晃动情况，消除了管路高频振动的问题。

关键词: 关键词：凝结水量变化, 水调门晃动, 管道振动, 改造方案, 定位器换型

Abstract: Abstract:In a 600MW unit, the opening of the water inlet adjusting valve on the deaerator changed rapidly due to serious reduction of the condensate water flow, the automatic water level adjustment function had not been realized, and the positioner was damaged repeatedly due to the highfrequency vibration of the pipeline. The reasons of vibration of the condensate pipeline were analyzed. The reformation scheme was proposed. After the reformation, the rapid change fault of the opening of the water inlet adjustment valve caused by reduction of the condensate water flow did not occur again, and the highfrequency vibration of the pipeline was eliminated.

Key words: Key words:variation of condensate water flow, rapid change of water inlet valve opening, pipeline vibration, reformation scheme, positioner type replacement

赵四海，葛冠杰. 600MW亚临界供热机组除氧器上水调门晃动处理[J]. 华电技术, 2013, 35(11): 52-53.

ZHAO Sihai, GE Guanjie. Treatment measures of rapid change of water inlet valve opening on the deaerator of 600MW subcritical heatsupply unit [J]. Huadian Technology, 2013, 35(11): 52-53.

[1]	周楠, 梁秀进, 李壮. 燃煤机组白色烟羽治理方案经济性分析[J]. 华电技术, 2020, 42(9): 63-68.
[2]	黄小军. 600MW机组高压加热器启动过程中管道振动分析与治理[J]. 华电技术, 2017, 39(4): 48-49.
[3]	舒茂龙. 大型空冷机组ETS优化与改造简析[J]. 华电技术, 2016, 38(4): 27-29.
[4]	朱晋杰. 燃气轮机进气系统防雾霾技术研究[J]. 华电技术, 2015, 37(7): 62-63.
[5]	谢亚军. 燃气轮机进气过滤系统的改造[J]. 华电技术, 2013, 35(7): 64-65.
[6]	徐斌;莘守亮;李继元;谷文胜. 脱硫系统无旁路改造方案分析[J]. 华电技术, 2013, 35(3): 64-67.
[7]	侯星恒;肖峰. 某电厂厂用电系统供电可靠性的改进[J]. 华电技术, 2012, 34(S1): 19-20.
[8]	郭伯春. 多点汇合式取样在提高凝汽器真空度测量准确性中的应用[J]. 华电技术, 2012, 34(3): 7-9.
[9]	郭伯春;肖胜. 引风机高压变频控制策略与优化[J]. 华电技术, 2011, 33(9): 56-58.
[10]	吴宝华;刘慧. 高压变频调速装置在凝结水泵上的应用[J]. 华电技术, 2011, 33(2): 27-29.
[11]	王娇玲;肖敏;赵树平. 凝结水泵“一拖二”变频改造热控方案[J]. 华电技术, 2010, 32(S1): 12-13.
[12]	朱宝森;刘彬;刘尊平;孙光玉. 超临界机组双背压凝汽器抽气系统改造[J]. 华电技术, 2010, 32(6): 9-11.
[13]	李玉伟. 高效过滤器工况分析及技术改造方案[J]. 华电技术, 2010, 32(5): 63-67.
[14]	陈建军. 烟囱运行工况分析及防腐改造方案[J]. 华电技术, 2010, 32(12): 78-80.
[15]	羊世勇. 一级过速保护存在的问题及其技术改造方案[J]. 华电技术, 2010, 32(11): 50-51.