邹县电厂2020t/h锅炉煤种变化后的燃烧调整

华电技术 ›› 2010, Vol. 32 ›› Issue (8): 54-57.

邹县电厂2020t/h锅炉煤种变化后的燃烧调整

刘三

华电国际邹县发电厂，山东邹城273522

收稿日期:1900-01-01 修回日期:1900-01-01 出版日期:2010-08-25

Combustion adjustment of 2020t/h boiler in Zouxian Power Plant responding to changed coal grade

LIU San

Huadian International Zouxian Power Plant, Zoucheng 273522, China

Received:1900-01-01 Revised:1900-01-01 Published:2010-08-25

摘要/Abstract

摘要： 华电国际邹县发电厂三期2020t/h锅炉原设计燃用当地烟煤，近期由于煤炭形势紧张，燃料品质变化很大。煤种变化后一段时间内，炉燃烧不稳定，常出现燃烧不稳定现象或负压大幅晃动，蒸汽、再热蒸汽温度达不到要求，至因煤质差而导致锅炉灭火事故，给机组的稳定运行和经济运行带来了很大的隐患。分析了造成该种情况的主要原因并提出了针对性的解决办法，得了较好的效果。

关键词: 锅炉, 燃烧器, 燃烧调整, 煤种, 稳定性

Abstract: The designed coal of the 2020t/h of Huadian International Zouxian Power Plant project phase III is local soft coal. For the near term, the fired coal quality was changed greatly due to the insufficient coal supply. In a certain period after the coal grade was changed, the unstable boiler combustion was often occurred or the furnace negative pressure was rocked in largescale amplitude, and the temperature of main steam and reheated steam can not reach the required value; even the boiler flame out accident was happened. This became a serious potential hazard for stable and economical operation of unit. The reasons of this fault were analyzed. The relevant solution was proposed, and better result had been obtained.

Key words: boiler, burner, combustion adjustment, coal grade, stability

刘三. 邹县电厂2020t/h锅炉煤种变化后的燃烧调整[J]. 华电技术, 2010, 32(8): 54-57.

LIU San. Combustion adjustment of 2020t/h boiler in Zouxian Power Plant responding to changed coal grade[J]. Huadian Technology, 2010, 32(8): 54-57.

[1]	童家麟, 张岩, 刘文胜, 茅建波, 叶学民. 对冲燃烧锅炉掺烧污泥炉内燃烧及碱金属分布模拟研究[J]. 综合智慧能源, 2024, 46(8): 50-58.
[2]	卓超然, 辛杰, 洪涵卓, 安邦, 李宁. 弱电网条件下并网逆变器阻抗模型的建立方法综述[J]. 综合智慧能源, 2024, 46(6): 88-101.
[3]	张心怡, 杨波. 考虑构网型和跟网型变流器的孤岛微电网小信号稳定性分析[J]. 综合智慧能源, 2024, 46(2): 12-18.
[4]	孟强, 杨洋, 熊亚选. 添加纳米SiO₂熔盐传热储热稳定性能研究[J]. 综合智慧能源, 2023, 45(9): 32-39.
[5]	蒋雨辰, 李清扬, 胡勋. 基于微波热解技术制备生物炭的研究进展[J]. 综合智慧能源, 2023, 45(5): 46-62.
[6]	孙健, 秦宇, 王寅武, 吴可欣, 戈志华. 基于新型工质热泵的烟气余热回收优化温度研究[J]. 综合智慧能源, 2023, 45(4): 19-25.
[7]	刘会强, 郭裕, 邢华栋, 慕腾, 刘建强, 张爱军. 基于前馈功率解耦控制的光伏电站系统稳定性研究[J]. 综合智慧能源, 2023, 45(3): 17-23.
[8]	张靖, 刘宇宙, 贺贝贝, 赵凌. 燃料电池金属有机框架质子膜材料研究展望[J]. 综合智慧能源, 2022, 44(8): 97-106.
[9]	闫新春, 曹欢, 华云鹏. 基于人工智能的锅炉受热面管壁温度预测[J]. 综合智慧能源, 2022, 44(3): 58-62.
[10]	丛星亮, 谢红, 苏阳, 张骏, 程英捷. 660 MW超超临界二次再热机组深度调峰试验研究[J]. 华电技术, 2021, 43(5): 64-69.
[11]	刘义斌, 刘旋坤, 宋刚, 杨欣华, 张缦, 杨海瑞. 350 MW超临界煤粉锅炉全燃准东煤的运行优化研究[J]. 华电技术, 2021, 43(12): 79-84.
[12]	陈全喜, 付江涛. 市政污泥耦合燃煤电厂发电关键因素分析与展望[J]. 华电技术, 2021, 43(10): 50-60.
[13]	谭雪梅, 刘世杰, 赵冰, 巩太义, 王家林, 胡南. 循环流化床锅炉气固两相流换热研究进展[J]. 华电技术, 2021, 43(10): 61-67.
[14]	刘秀如, 李佩佩, 王先鹏, 芦旭阁, 王志强. 锅炉烟气酸露点研究现状及展望[J]. 华电技术, 2020, 42(9): 45-55.
[15]	孙刘涛, 闫永宏, 陈登科, 彭政康, 孙锐. 燃烧器钝体扩展角度对半焦/烟煤混燃及NOx排放的影响[J]. 华电技术, 2020, 42(7): 20-27.