Integrally replacing method of heat pipe type air preheater

Abstract

Abstract: Some problems, such as the serious wear, the decreased heat exchange efficiency and the increased air leakage, existed in heat pipe type air preheater of boiler No.7 of Tianjin Junliangcheng Power Generation Corporation Limited. The construction technical scheme for integrally replacing the heat pipe type air preheater and relevant safety precautions were introduced in detail. The comparison of the test data after replacing with that before replacing indicates that after the heat pipe type air preheater had been replaced, the operation situation was obviously improved, and the prospective effect was achieved. 

Key words: heat pipe type air preheater, wear, air leakage, replacing scheme, effect

HOU Zhicheng. Integrally replacing method of heat pipe type air preheater[J]. Huadian Technology, 2011, 33(3): 64-66.

[1]	ZHANG Lidong, LI Pei, JIANG Tieliu, LI Qinwei, ZHANG Lei, XU Feng, MENG Xin. Numerical simulation on the wind blocking and speed increasing effect of trough solar arrays [J]. Integrated Intelligent Energy, 2024, 46(6): 1-7.
[2]	WANG Yongli, WANG Yanan, MA Ziben, QIN Yumeng, CHEN Xichang, TENG Yue. Effectiveness evaluation on energy trading systems taking blockchain technology [J]. Integrated Intelligent Energy, 2024, 46(4): 78-84.
[3]	LI Feifei, XU Huiwei, WANG Shuhong, CUI Jindong. Measurement analysis on carbon emissions from agriculture industry in Jilin province and the influencing factors [J]. Integrated Intelligent Energy, 2023, 45(8): 36-43.
[4]	LI Yizhe, WANG Dan, JIA Hongjie, ZHOU Tianshuo, CAO Yitao, ZHANG Shuai, LIU Jiawei. Diverse modeling methods for energy hubs in integrated energy systems and their typical applications [J]. Integrated Intelligent Energy, 2023, 45(7): 22-29.
[5]	ZHU Shasha, LI Zongbao, DENG Yatian, WANG Xin, JIA Lichao. Application of alloy nanoparticles in the anodes of hydrocarbon solid oxide fuel cells [J]. Integrated Intelligent Energy, 2022, 44(8): 33-42.
[6]	LIN Yu. Numerical simulation of spraying effects and impacts on the desulphurization tower shell with two types of nozzles [J]. Huadian Technology, 2020, 42(9): 16-25.
[7]	HOU Zhifu1，WEI Xiaoyi2，XING Shutao2，ZHAO Zhouming1，ZHANG Zhihua1. Research on low-temperature waste heat flash evaporation technology applied in desulfurization wastewater zero discharge of 300 MW units #br# [J]. Huadian Technology, 2020, 42(3): 31-36.
[8]	YU Shilin, JIN Limei, TAN Houzhang, ZHANG Gaoxiong, REN Qiaoli. Exploration on causes of SCR catalyst wear and the optimization scheme [J]. Huadian Technology, 2020, 42(12): 7-13.
[9]	SONG Baoyu，YUE Hao. Optimization of air preheater leakage control system in 670MW unit [J]. Huadian Technology, 2019, 41(9): 76-77.
[10]	JIN Jun，ZHONG Xihu，LI Guangwei. Analysis of temperature deviation of exhaust flue gas in air preheater [J]. Huadian Technology, 2019, 41(6): 53-56.
[11]	中国华电科工集团有限公司，北京〓100070. Study on the influence of fresh water drainage on seawater desulphurization system [J]. Huadian Technology, 2019, 41(5): 1-7.
[12]	YU Zhongyong. Brief analysis of LGGH operation and maintenance in thermal power plant [J]. Huadian Technology, 2018, 40(8): 39-41.
[13]	WU Xiaoming, GUAN Xiangfeng, JIAO Yulong, SUN Zhengrui. Reason analysis and prevention scheme of tube blowing loss in lowtemperature reheater [J]. Huadian Technology, 2018, 40(8): 54-56.
[14]	ZHOU Zhou, LIU Nan. Evaluation method of energy saving effect of low temperature economizer [J]. Huadian Technology, 2018, 40(4): 28-29.
[15]	XU Jinlei, FU Hongjun. Discussion on wearing repair technology of rotor journal of MS9001E gas turbine generator [J]. Huadian Technology, 2018, 40(10): 12-14.

Integrally replacing method of heat pipe type air preheater

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments