Problems of condenser rubber ball cleaning device occurred after pole changing reformation of circulating water pump and countermeasures

Huadian Technology ›› 2012, Vol. 34 ›› Issue (10): 49-51.

• 技术交流 • Previous Articles Next Articles

Problems of condenser rubber ball cleaning device occurred after pole changing reformation of circulating water pump and countermeasures

XIAO Chengming

Guodian Huangjinbu Power Generation Company Limited, Yugan 335101, China

Received:1900-01-01 Revised:1900-01-01 Online:2012-10-25 Published:2012-10-25

Abstract

Abstract:

In the Guodian Huangjinbu Power Generation Company Limited, after the circulating water pump motor had been reformed by pole changing method, when

the lowspeed circulating water pump operates, the rubber ball recovery rate of the condenser rubber ball cleaning device was very low (below 50%). The

reason of low ball recovery rate was analyzed. At present，by improving the condition for putting the rubber ball cleaning device into operation, the rubber

ball recovery rate achieves above 95% when the lowspeed circulating pump operates, which can satisfy the requirement of the condenser cleaning.


Key words: circulating water pump, pole changing, rubber ball cleaning device, rubber ball recovery rate, measure

XIAO Chengming. Problems of condenser rubber ball cleaning device occurred after pole changing reformation of circulating water pump and countermeasures[J]. Huadian Technology, 2012, 34(10): 49-51.

[1]	LIU Xiuru, LI Peipei, WANG Xianpeng, LU Xuge, WANG Zhiqiang. Review and prospect of researches on boilers´ flue gas acid dew point [J]. Huadian Technology, 2020, 42(9): 45-55.
[2]	YANG Mingming. Research on wind turbine power curve based on Nacelle Transfer Function [J]. Huadian Technology, 2020, 42(5): 50-54.
[3]	LIU Zhimin1,2, DING Yang1, XU Tingting1,BAI Yunshan1. Research on gas turbine combustion pressure fluctuation and the key technologies for its measurement [J]. Huadian Technology, 2019, 41(9): 1-5.
[4]	LI Haiyang，WANG Renlei，YOU Liangzhou，HENG Shiquan. Experimental study of dissolved oxygen’s effect on dissolved hydrogen analyzer of the main steam [J]. Huadian Technology, 2019, 41(7): 27-30.
[5]	WANG Xueli. Reasons analysis for tube blasting and preventive measures for superheater of 1000MW supercritical boiler [J]. Huadian Technology, 2019, 41(7): 70-72.
[6]	YE Luo，WU Jundong，CHEN Xian. Operation analysis of low temperature economizer system [J]. Huadian Technology, 2019, 41(6): 50-52.
[7]	WANG Zhoujun1,2，LI Xinghua2，TANG Lijun1，DUAN Quansheng2. Study on flow mixing and equalizing technique of primary air at inlet of medium speed coal mills [J]. Huadian Technology, 2019, 41(5): 17-21.
[8]	ZHANG Jibing，QIAO Xiaosan. Calculation and comparison of carbon emissions based on the default value and measured value of raw coal emission factor [J]. Huadian Technology, 2019, 41(3): 73-75.
[9]	SONG Xin. Analysis and solution for temperature fluctuation of turbine shaft seal steam [J]. Huadian Technology, 2019, 41(2): 46-48.
[10]	CAI Liangliang，GONG Shimin，TANG Bin，LI Shuai，ZHANG Lin，YUAN Quan. Research on automatic and seamless switching technology for virtual backup measurement and control units in smart substations [J]. Huadian Technology, 2019, 41(10): 30-34.
[11]	ZHU Hao. Discussion on the problem of power supply with different grids in thermal power plant [J]. Huadian Technology, 2018, 40(9): 25-27.
[12]	ZHENG Liwen. Measures to improve heating capacity of thermoelectric gas turbine in South Xinjiang Thermal Power Plant [J]. Huadian Technology, 2018, 40(9): 28-29.
[13]	HUANG Chengbin, ZHANG Yulin. Method for improving measurement accuracy of soft ground backfilling project [J]. Huadian Technology, 2018, 40(8): 21-22.
[14]	TANG Guorui, YOU Liangzhou, LI Zhuang. The influence and prevention measure for the integration of IDF and BF in the boiler furnace and flue gas system [J]. Huadian Technology, 2018, 40(8): 23-25.
[15]	ZHU Xueping. Causes and countermeasures of MGGH leakage [J]. Huadian Technology, 2018, 40(8): 47-49.

Problems of condenser rubber ball cleaning device occurred after pole changing reformation of circulating water pump and countermeasures

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments