Analysis and control of steam overtemperature in separated platen superheater outlet of 600MW supercritical boiler at initial startup stage

Huadian Technology ›› 2011, Vol. 33 ›› Issue (12): 15-17.

• 专题综述 • Previous Articles Next Articles

Analysis and control of steam overtemperature in separated platen superheater outlet of 600MW supercritical boiler at initial startup stage

XIAO Lizheng, LIU Xiaojun

Hubei Huadian Xiangyang Power Generation Corporation Limited, Xiangyang 441141, China

Received:1900-01-01 Revised:1900-01-01 Published:2011-12-25

Abstract

Abstract: The attemperating water system is not designed in the inlet of the separated platen superheater of the 600MW supercritical boiler manufactured in Shanghai Boiler Works Corporation Limited. At the initial startup stage of the boiler, due to the plasma ignition and the larger heat loss of the boiler in wetstate operation stage, the steam temperature in outlet of the separated platen superheater is easily exceeded the limit. Aiming at this problem, based on analysis and site practice, the effective method to control the outlet steam temperature was found.

Key words: supercritical boiler, overtemperature of separated platen, reason, measure

XIAO Lizheng;LIU Xiaojun. Analysis and control of steam overtemperature in separated platen superheater outlet of 600MW supercritical boiler at initial startup stage[J]. Huadian Technology, 2011, 33(12): 15-17.

[1]	LI Fangyi, LI Nan, ZHOU Yan, XIE Wu. Prediction on the regional carbon emission factor for power generation based on multi-dimensional data and deep learning [J]. Integrated Intelligent Energy, 2023, 45(8): 11-17.
[2]	LIU Yixian, WANG Yubin, YANG Qiang. High fault-tolerant distribution network state estimation method based on gated graph neural network [J]. Integrated Intelligent Energy, 2023, 45(6): 1-8.
[3]	FU Hao, ZOU Hualei, ZHANG Tengfei. Intelligent fault reasoning method for the substation monitoring system based on LSTM [J]. Integrated Intelligent Energy, 2022, 44(12): 11-17.
[4]	CONG Xingliang, XIE Hong, SU Yang, ZHANG Jun, CHENG Yingjie. Experimental study on deep peak-load shaving of a 660 MW ultra-supercritical secondary reheating unit [J]. Huadian Technology, 2021, 43(5): 64-69.
[5]	LIU Yibin, LIU Xuankun, SONG Gang, YANG Xinhua, ZHANG Man, YANG Hairui. Study on the operation optimization of 350 MW supercritical pulverized coal-fired boiler firing 100％ Zhundong coal [J]. Huadian Technology, 2021, 43(12): 79-84.
[6]	LIU Xiuru, LI Peipei, WANG Xianpeng, LU Xuge, WANG Zhiqiang. Review and prospect of researches on boilers´ flue gas acid dew point [J]. Huadian Technology, 2020, 42(9): 45-55.
[7]	YANG Mingming. Research on wind turbine power curve based on Nacelle Transfer Function [J]. Huadian Technology, 2020, 42(5): 50-54.
[8]	LIU Zhimin1,2, DING Yang1, XU Tingting1,BAI Yunshan1. Research on gas turbine combustion pressure fluctuation and the key technologies for its measurement [J]. Huadian Technology, 2019, 41(9): 1-5.
[9]	LI Haiyang，WANG Renlei，YOU Liangzhou，HENG Shiquan. Experimental study of dissolved oxygen’s effect on dissolved hydrogen analyzer of the main steam [J]. Huadian Technology, 2019, 41(7): 27-30.
[10]	WANG Xueli. Reasons analysis for tube blasting and preventive measures for superheater of 1000MW supercritical boiler [J]. Huadian Technology, 2019, 41(7): 70-72.
[11]	YE Luo，WU Jundong，CHEN Xian. Operation analysis of low temperature economizer system [J]. Huadian Technology, 2019, 41(6): 50-52.
[12]	WANG Zhoujun1,2，LI Xinghua2，TANG Lijun1，DUAN Quansheng2. Study on flow mixing and equalizing technique of primary air at inlet of medium speed coal mills [J]. Huadian Technology, 2019, 41(5): 17-21.
[13]	WANG Xiaojun. Exploration on feed water flow control at initial stage of startup of a 600MW supercritical boiler [J]. Huadian Technology, 2019, 41(4): 74-75.
[14]	ZHANG Jibing，QIAO Xiaosan. Calculation and comparison of carbon emissions based on the default value and measured value of raw coal emission factor [J]. Huadian Technology, 2019, 41(3): 73-75.
[15]	KE Hao，LI Zhenliang，WANG Xi. Cause analysis and countermeasures for tube burst of hightemperature superheater in supercritical boiler [J]. Huadian Technology, 2019, 41(2): 26-27.

Analysis and control of steam overtemperature in separated platen superheater outlet of 600MW supercritical boiler at initial startup stage

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments